OES火花直读光谱仪
XRF荧光光谱仪
进口超声波探伤设备及探头
国产超声波探伤设备及探头
涡流检测设备及探头
磁粉探伤机
渗透检测流水线
磁粉检测耗材和附件
渗透检测耗材和附件
紫外线灯(黑光灯)
Western Instrument 磁轭
WesternInstrumeng磁轭
您现在的位置:上海澜睿机电科技有限公司 > 产品中心> 涡流检测设备及探头

我们已经构建同时注入多频涡流设备超过其他任何公司。码头等48微涡流系统持续我们的传统的提供多频涡流系统最小和最轻的。
尽管规模小,仅为2.5 x 7 x 16英寸和低体重只有5磅等微码头是一个高速度、功能齐全的4频率,8通道涡流系统可以检查任何铁磁或non-ferromagnetic换热器管今天在服务。

ECT 48 Specifications参数

ECT 48 Main Features特点

PROBE TYPES探头形式
Differential, Absolute, and Send/Receive
with industry standard 4-Pin MS Connector

The ect 48 Eddy Current System, designed for inspecting ferro and non-ferromagnetic heat exchanger tubes,has up to four simultaneous injection frequency channels and two mixers.

ECT 48个涡流系统,用于检测铁和non-ferromagnetic热交换器管,有四个同时注入频率通道和两个搅拌机。

BRIDGE IMPEDANCE 75 ohm

·         Simultaneous Injection (SI)

·         Simultaneous Sampling (SS)

·         Up to 12,000 Hz sample rate, each channel, allows up to 10 feet per second probe speed at over 100 samples/inch.

·         12000 Hz采样率,每个通道,允许10英尺每秒探测速度超过100样本/英寸。

·         Automatic data analysis.

·         自动数据分析

·         Save and recall unlimited test setups.

·         测试结果无限制保留和重复使用

·         Defect signals are highlighted in real time during recording or playback.

·         记录和回放时,缺陷信号实时突出标示

·         Four independently selected simultaneous frequencies.

·         4个独立选择的同步频率

·         Digital Signal Processing (DSP) HP & LP filtering provides lower noise.

·         数字信号处理(高通和低通过滤提供低噪音水平)

·         Independent horizontal and vertical display scaling.

·         Signal phase and amplitude measurement functions.

·         独立的水平和垂直显示, 信号相位,幅值测量功能

·         Defect depth measurement functions.

·         缺陷深度测量功能

·         Standard printer interface.

·         标准打印接口

·         Single keystroke data acquisition.

·         单键数据获取

·         Single keystroke data playback with analysis.

·         单键数据回放和分析

·         Optional ect 48 Data Analysis Software.

·         可选ECT48 数据分析软件

·         Optional ect Frequency Transforms* use eddy current signals in the frequency domain, making it easy to distinguish between magnetic inclusions, roll stops, and serious defects.

·         可选频率转换器,用涡流信号在频率范围内,使其容易区分磁性夹杂,滚轮停印和严重的缺陷

·         Optional ect Data Storage Software stores and recalls eddy current signals on disk.

·          

·         Optional ect Report Software reads the defect listprovided by
the ect 48 Data Analysis Software and provides tube sheet maps
color-coded based on defect depth.

·         16 16-Bit Analog-to-Digital Conversion so all channels are sampled in
the same microsecond.

ECT 48 Accessories附件

INCLUDED ACCESSORIES

1.    Power Cord

2.    Manual

OPTIONAL ACCESSORIES

1.    Carbon Steel Filter Amplifier for simultaneous Remote Field and
Near FieldTM inspecting of ferrous tubes

2.    ect 48 Data Analysis Software

3.    ect 48 Frequency Transform Software*

4.    ect Report Software

5.    Built-in DVD writer

6.    Transit Case

7.    Separate Data Analysis System

8.    Available in Micro Dock configuration

9.    1。碳钢过滤器同时远程领域和放大器附近FieldTM亚铁管的检查
2。ECT 48数据分析软件
3 ECT 48 *频率转换软件
4 ECT48 报告软件
5。内置的DVD的作家
6。交通情况
7所示。单独的数据分析系统
8。在微码头配置

ect 48 Ordering Information

The ect 48 Micro Dock Eddy Current System has many more features than can be described on this brochure.

ECT 48微涡流系统有许多更多的功能比可以描述在这个手册。

FREQUENCY CHARACTERISTICS频率

RANGE范围:40 Hz to 5 MHz Stability稳定性 + 100 PPM

TRANSFER CHARACTERISTICS转换特性, 4 Frequencies, One Probe4个频率,一个探头

SENSITIVITY灵敏度:135 Volts/Ohm min. at 30 kHz at max. gain setting

GAIN增益:90 db at maximum gain setting最大增益条件下90分贝

DRIFT飘移:Less than 0.1 Volts per hour at 60db gain with probe

60分贝下不足0.1V

NOISE噪音: Less than 30 mV P-P at nominal gain正常增益条件下小于30mV

LP Filter: 5 to 1,000 Hz

HP DSP FILTER: 0.1 to 14 Hz

LP DSP FILTER: 12 to 1,440 Hz

BALANCE平衡: High speed successive approx. electronic balance高速连续电子平衡

MULTIPLEX MODE多通道模式: 32 Channels

STORAGE DISPLAY MODES WITH 1280 x 1024 SCREEN 储存显示模式带1280x1024显示屏

12 XY Impedance Planes and 2 Strip Charts

12个XY独立平面和两个Strip Charts

EDDY CURRENT CHANNEL CONTROLS通道控制

GAIN增益: 999 Linear Steps线性

PHASE相位: 360 Degrees

FREQUENCY频率: 20 Hz – 5 MHz in 1 Hz Steps

VOLTS/DIVISION电压: Separate Horiz. & Vert.水平和垂直 .06, .13, .25, .5, 1, 2, 4, 8, 16 V/Div

BALANCE平衡: Each channel independent or all simultaneously每个通道独立或者所有通道同时

POSITION定位: + Full Screen, Horizontal and Vertical全屏,水平和垂直

MIXER CONTROLS

INPUT PHASE输入相位: 360 Degrees

OUTPUT PHASE输出相位: 360 Degrees

HORIZ. WEIGHT水平重量: 0 – 999%

VERT. WEIGHT垂直重量: 0 – 999%

VOLTS/DIVISION电压: Separate Horiz. & Vert水平和垂直. .06, .13, .25, .5, 1, 2, 4, 8, 16 V/Div

POSITION定位: + Full Screen, Horizontal and Vertical全屏,水平和竖直

CANCEL取消: Automatic自动

SYSTEM CONTROLS系统控制

SAMPLE RATE取样速率: 100 Hz to 12 kHz, All Channels Simultaneously

CODE COMPLIANCE规范标准

Meets or exceeds ASME Section V & XI requirements

POWER REQUIREMENTS电源要求

VOLTAGE电压: 90-130 and 185-270 Vac auto selected

FREQUENCY频率: 50-60 Hz

POWER功率: 100 Watt Max

 
关于我们 新闻动态 荣誉证书 人才招聘

上海澜睿机电科技有限公司 版权所有 严禁复制 2016
网站备案号:沪ICP备16033523 上海网络营销|营销型网站上频